admin

CozyParts.com, Inc is a web based Lennox repair parts products retailer that is been operating their web based business since 2002.

LENNOX CBX25UH and CBX25XHV air handler enhancement

Lennox recently announced upgrades to the CBX25UH and CBX25UHV air handler series.

 

1. Cabinet stability

Increased cabinet stability, including when access doors are removed in horizontal installations
Redesigned cabinet wrapper with hem across front edge
Redesigned coil support and hold down brackets
Redesigned cabinet brace for easier blower removal

2. Improved piping routing

Improve routing of refrigerant piping to allow for more optimal TXV bulb placement inside cabinet
No need to place bulb outside of cabinet at installation

3. Easier access

Single gauge metal cabinet allows for easier removal of high and low voltage redesigned knockouts
Metal condensate drain knockouts converted to rubber snap-in grommets for easier access
Electric heat knockouts replaced with a cover plate for easier removal during installation of electric heatstrips

4. Standardized cabinet fasteners

Standardized to a single thread size and clip fasteners throughout cabinet

5. Improved fit and finish

Enhanced insulation installation methodology for improved adhesion
Tighter and consistent bend radius (cabinet corners and top caps)
Improved filter rail design for easier installation and removal

New Lennox Quantum™ coil improves reliability

More than 10 years of research and design went into the development of the Lennox Quantum condenser coils. These fortified aluminum tube and fin coils eliminate dissimilar metals which helps guard against fin loss due to galvanic corrosion. Although the coil is constructed of a fortified copper, the field connections to the unit are copper, allowing the contractor to use standard installation practices to install the unit.

Lennox Announces Guidelines For Flood Damaged Furnaces and Air Conditioners

This information is created from Lennox Application Note ACC-63-11

Flood Damaged Heating & A/C Equipment

10/9/2015

In the event Lennox HVAC equipment has been flood damaged or rendered inoperable due to a severe storm, the following steps should be taken before returning the equipment to operation:

  • Any unit that is or has been partially or completely submerged must have the electrical power supply disconnected immediately. The fuel supply to gas or oil burning equipment must be shut off.
  • Complete equipment service must be performed on the equipment. Safe and proper operation of the equipment must be verified. Failure to do so can cause further property damage and/or personal injury.
  • The extent of the damage will depend on the depth of the flood water, water type (fresh, brackish, etc) and the length of time that the unit was submerged.

Gas or Oil Furnaces & Heating Sections of Residential Package Units

  1. Ensure the electrical power supply to the equipment is off.
  2. The equipment must be thoroughly cleaned. This may require removal and disassembly dependent upon depth of water and length of time submerged.
  3. All electrical and safety components, such as those listed below, that have been under water must be removed and replaced with a new part:
    • Ignition control
    • Gas valve
    • Primary and secondary limits
    • Flame rollout switch
    • Combustion air inducer and pressure switch
    • Igniter
    • Blower motors
  4. Burners that have been under water must be thoroughly cleaned and/or replaced.
  5. Equipment insulation is secured to the cabinet with water-soluble glue. If insulation has been under water, it must be replaced with insulation of the same type, density and thickness as the original.
  6. Clean and thoroughly dry all electrical connections and any damaged wiring must be replaced.
  7. After repairs have been completed, an operational safety check must be performed on the equipment.
  8. The correct operation of all safety devices must be verified.

Air Conditioning or Heat Pump Systems & Refrigerant Sections of Residential Package Units

If the refrigerant circuit is damaged resulting in a refrigerant leak or is open to the atmosphere and has been under water, the complete system – (outdoor unit, refrigerant lines and evaporator or air handler) must be replaced.

If the refrigerant circuit is NOT open to the atmosphere, the following steps must be taken:

  1. Ensure the electrical power supply to the system is off.
  2. The equipment must be thoroughly cleaned, including the outdoor coil and evaporator in a furnace or air handler installation. This may require removal and disassembly dependent upon depth of water and length of time submerged.
  3. All electrical and safety components, such as those listed below, that have been under water must be removed and replaced with a new part: (this applies to both the indoor and outdoor equipment)
    • Electronic controls, defrost controls or electric heat controls and sequencers
    • Contactors
    • Motors
    • Refrigerant Pressure Switches (non-hermetically sealed)
  4. Equipment insulation is secured to the cabinet with water-soluble glue. If insulation has been under water, it must be replaced with insulation of the same type, density and thickness as the original.
  5. Clean and thoroughly dry all electrical connections and compressor terminals. Any damaged wiring must also be replaced.
  6. After repairs have been completed, an operational safety check must be performed on the equipment.

The correct operation of all safety devices must be verified.

System Accessories

All system accessories, such as thermostats, air filters, indoor air quality equipment, electrical devices and the air distribution system, should be evaluated using the guidelines listed above.

Warranty

Flood damaged components are not covered by the Lennox limited warranty. New replacement parts carry a one-year limited warranty. Lennox further suggests making a thorough evaluation of the necessary repairs (labor and parts) in order to provide an accurate estimated the cost to the consumer. The estimate should also include an estimate for replacement equipment so the consumer can evaluate the options available and make the best decision for their situation and needs.

CozyParts announces special pricing on Lennox 83M0001 Circuit Board

We have special pricing on the Lennox 83M0001 (catalog number 83M00) just in time for those fall furnace tune ups. Many times when you switch to heat, you find out your ignition control is not ready for the winter. This price will remain in effect until our current inventory is depleted so don’t miss out!

Click here to view the 83M00, 83M001 Ignition Control Detail Page

 

Fight fall allergies with HEPA air filters that remove at least 99% of pollen and other particles.

Healthy Climate Solutions from Lennox offer the most effective ways to improve the quality of your home’s air. From the #1 Rated filtration system to whole-home dehumidification, there’s an innovative solution you can feel good about.

Not sure which solution is best for your home and family?

Lennox’s solution finder can guide you through the selection process, leading you to the indoor air quality systems that best address the issues you identify. You can access the Lennox solution finder using the link below:
http://www.lennox.com/healthy-indoor-air/

​Introducing the Lennox iComfort S30 Smart Thermostat

Adapts to your life. Perfectly.

Schedules may change. The weather may change. Even the air quality in your neighborhood may change. Introducing the new Lennox iComfort S30 that adapts to your life and to the changing environment to deliver the ultimate comfort, energy savings, and peace of mind. http://www.lennox.com/icomforts30/

Never Forget to Change Your Air Filter Again… Free Reminder Service by Email

We all do it. We forget to change the air filter or we never get around to changing the media in the humidifier. There is good news for us that are forgetful or just procrastinate. CozyParts.com offers a free reminder service that can remind you when it is time to change your air filter, humidifier media, UV lamps, or even your smoke detector or thermostat batteries. Just sign up for a free account at http://www.cozyparts.com/reminder-service/

CozyParts.com is a full service parts and maintenance supplier dedicated to Lennox Heating and Cooling products.

Lennox ComfortSense 7500 available.

The Lennox ComfortSense 7500 programmable thermostat delivers precise, sophisticated control and multiple energy-saving features. All accessed through a brilliant, modern touchscreen interface.

Features and Benefits

Energy Efficiency

Programable 7-day or 5-day/2-day temperature scheduleversatile programming options offer custom comfort and energy savings

Dual-fuel capabilityincreases the efficiency of dual-fuel heating systems by automatically alternating between gas and electric operation

One-Touch Away Modeturns down heating or cooling with one touch to save energy when no one is home

Energy Reportsshow how often and how long the heating or cooling system has run for the month

Home Comfort

Automatic changeoverdecides between heating and cooling operation, depending on indoor temperature

Smooth Setback Recoveryhelps make sure the temperature in your home is right where you want it, when you want it by starting the heating or cooling up to 2 hours in advance

Humidity Controldesigned to work with the Humiditrol Whole-Home Dehumidification System to adjust the home’s humidity level

Reliable Performance

Touchscreen displayfeatures a large (4.3″) easy to use display with adjustable brightness

Customizable remindersallow you to set a series of service and parts replacement reminders which display on the home screen

Filter Reminderreminds you when its time to change the filter

Outdoor Temperature Displayshows the temperature outside your home (requires optional sensor)

Universal thermostatworks with conventional and heat pump systems, supporting up to four stages of heat and two stages of cooling.
Compatible with Lennox-brand non-communicating equipment and most other brands of heating and cooling equipment

Win up to $10,000 in Lennox equipment from Lennox!

Lennox is giving you a chance to be anEnergy Savings Superstar for a chance to win up to $10,000 in Lennox equipment! Enter today by submitting an energy-savings tip and photo on the Lennox website

https://www.lennox.com/landing/energy_savings_superstar_contest/

 

CozyParts.com, Inc. announces new web site launch to support Lennox products.

After months of planning and work we have finally got our new web site launched. While the overall content has remained the same, we have applied a new skin and all of the latest security updates. We look forward to proving many new products and additional features in the future.

Here is the major updates:

Parts Store:

New skin and new security updates as well as a easier to use administration area, particularly for phone orders. You are no longer required to have an account to complete the checkout process.

Community Forum:

The forum is functionally the same, but we did theme it to match the store.

Filter Reminder Service:

Function remains the same. but a new theme was applied Also new security updates.

Blog:

Our blog has been updated with the newest database security and the blog software was updated to the newest software. We also have a new theme. The theme on the blog will continue to receive updates.

Customer Support Ticketing System:

The customer support system has not changed. We do plan for an updated system in the near future.